👯 Ford Mondeo Mk4 Gearbox Problems

18,974. Location. Fylde Coast, Lancashire. Shivy011 said: titanium X 2.0TDCI. Exactly my car (mk4.5). It's great and the gearbox is smooth and predictable. A bargain for the £3800 I paid for it last July (high miles at 139k - since done another 8k trouble free). My wife has a mk4 Titanium X SPort 2.0 Ecoboost and the gearbox in that is a bit Check the condenser to see if it’s blocked by debris. If your condenser has taken damage or is clogged up, it can’t remove the heat from the refrigerant. Check to ensure that the electric fan over the condenser is engaging. If the cooling system works better on the highway (where fans aren’t needed), your Mondeo may be having fan issues Modern ECU's will typically prevent actual startup when cranking if certain parameters aren't within a set range. I know from using Forscan on my MK2 Focus 1.8 TDCi that if the fuel rail pressure isn't above a certain figure there is a specific code/PID that is YES/NO, YES = as far the ECU is concerned it will try to start the car and NO = no matter how long I crank it won't start. Not sure what gearbox it is, but it's a Getrag Powershift box with wet clutches, fitted to my 2012 Mk4.5 Mondeo 2.0 Ecoboost. On Friday, I took it for its MoT, it failed it due to excessive oil leak. On my return home, sure enough, there's a large puddle of oil where the car was parked. May 30, 2023 by Jason. If your Ford Mondeo has a faulty throttle body, it can cause it to run terribly. Common symptoms of a bad throttle body include dirt and grime, the check engine light, and an erratic idle. Your Mondeo’s throttle body controls the amount of air that enters the engine. You control the throttle body position with the gas The problem is a damaged seal on the gearbox. Fordhas produced a repair kit (part number: 1863642), so you’ll need to follow the procedure in your Haynes Mondeo manual for removing the affected seal, then fit the new one before reassembling the, making sure that all fastenings are done up to the correct torque. Brake Hose. The brake hose that attaches to the Mondeo’s caliper will often cause the brakes to stick. They may appear to be fine on the outside, but can break apart and collect debris on the inside. When this happens, it effectively traps pressure in the line. This keeps the brakes from releasing all of the way, and they stick as a result. I have a Mondeo MK4 which after getting a clucth done the steering started to get heavy when turning right only. The pump would make a whining noise also. The rear engine / gearbox mounting bracket is held onto the gearbox and sub frame by two 15mm bolts, one of the bolts is a few mm longer than the other one and if they are fitted the wrong Disconnect the wire for the parking sensors from the reverse light and see if they work. If on your car the reverse light circuit is controlled by the BCM then it may be sensing the increased current draw and is switching off the supply to the lights. I already tried removing the parking sensor's connection completely. 5.28 UK qt. 6 L. Transmission oil: WSS-M2C936-A. Manual transmission oil replacement for your 2011 Ford Mondeo Hatchback can be done on your driveway. The whole job will take about 30 – 60 minutes and will save you around $100. There are two plugs on the transmission - the drain plug at the bottom, and the refill plug on the side. .

ford mondeo mk4 gearbox problems